Theory and practice of meat processing (E-Journal) / Теория и практика переработки мяса
Not a member yet
240 research outputs found
Sort by
Use of iodine and selenium enriched fodder rations for production of fortified young lamb
Get PDFThe article is devoted to preventive measures to eliminate the problem of dysmicroelementosis in order to increase the productivity of young sheep. The article presents the results of studies of the influence of feeding rations on the growth and development of young sheep of the Edilbaev breed, on the level of their meat productivity and the qualitative characteristics of biologically fortified lamb. Feed additives based on Yoddar-Zn and DAFS-25 were added to the main ration of lambs at the age of four months, once a day, being added into a fodder mixture with concentrates. For the experiment the herd of lambs was divided to four groups of 25 heads each.The changes in live weight at the age of four, five, six and seven months were analyzed, and it was found that at the age of seven months, the absolute average weight gain in the experimental groups varied from 3.45 kg to 4.49 kg, in the control group it was 3.1 kg, while the largest live weight gain was recorded in group III which received both feed additives based on Yoddar-Zn and DAFS-25.There were no significant differences in the parameters of body measurements, with the exception of group III, where the chest circumference increased by 7.2%, and the height of a lamb at the withers increased in average by 8.1%. It was found that group III had the highest meat density coefficient, equal to 3.9, and the cross-sectional area of m. Longissimus dorsi was equal to 13.61 cm2. It was noted that the amount of free amino acids of the lamb group III is 18.8% higher than the meat of the control group. The lamb obtained from the animals of the experimental groups showed a higher protein content and less fat. The ratio of water to protein in all samples was slightly higher than 3.7, which corresponds to the Federa number for meat raw materials. Enriching the rations of the Edilbaevskoy sheep with feed additives Yoddar-Zn and DAFS-25 promotes the stimulation of growth and development of animals, increases the productivity and nutritional value of lamb
Edible insects as a source of alternative protein. A review
Get PDFThe current state and research priorities in the field of using insects as foods and their components are examined. At present, entomophagy is practiced in Africa, South America and Asia. It is shown that the growing world population, which is increasingly limited in resources upon the rising demand for animal protein, has stimulated the interest to new food sources that can include insects as future alternative sources of animal protein. In the forming global model based on the growing share of renewable energy sources, entomophagy fits in as a renewable source of food energy. Over the last decade, the potential of edible insects as a new ingredient has been studied. It is noted that edible insects can be produced with less environmental impact compared to cattle. Insects have a huge potential at all life cycle stages as a source of nutritional and active substances and are a rich source of animal protein, contain essential amino acids, minerals (K, Na, Ca, Cu, Fe, Zn, Mn and P), vitamins (В-group, А, D, Е, К and С) and unsaturated fatty acids. Assimilability of insect protein is 76–98%. Insect carbohydrates are represented mainly by chitin contained in a range from 2.7 mg to 49.8 mg/kg of fresh matter. There are data that different insect species can have immune stimulating, sugar reducing, antioxidant and anti-genotoxic activities, as well as the positive effect in cardiovascular and nervous disorders. In the western countries, different methods of insect processing were developed. The review summarizes advantages and risks of eating insects and legal practices of their consumption. Possible ways and strategies of stimulating edible insect consumption are analyzed taking into account that the majority of population in western countries reject the idea of eating insects. The review of performed studies notes the necessity to eliminate emotional and psychological barriers on the way of accepting edible insect consumption
Technology of enzymatic-acid hydrolysis of bone raw material in production of gelatine
Get PDFBone gelatin is an important and irreplaceable item widely used in the food industry and pharmaceutical production; it is also widely used in tissue engineering and other spheres. Due to widespread use of gelatin it is necessary to search for new safe and effective technologies for bone gelatin production. This research represents the results of enzymatic-acid hydrolysis of raw material in the process of gelatin production. The article presents the results of hydrolysis analyzes, the results of the main quality parameters of the obtained gelatin samples; and the major technological scheme for gelatin production is proposed here. As result of developed technology of enzymatic-acid hydrolysis of bone raw material with the ratio of raw material mass to the volume of solvent (HCl 1M and pepsin with an enzymatic activity of 40 units) as 1:9, duration of exposure: 180 minutes (3 hours), at the stage of demineralization, liming and de-ashing, we obtained samples of gelatin at yield rate of 12.1% from the initial mass of raw materials, which is 6.9% higher in comparison with the lowest yield of gelatin according to the proposed schemes. It is shown that the samples have a high protein mass fraction 91.4%, and a low fat mass fraction 0.4%, the obtained results indicate the high technological qualities of the obtained gelatin sample, this is also confirmed by high strength of gel according to Bloom scale, which value varies within the range of 290 ± 0.7 units
Exposure assessment to essential elements through the consumption of canned fish in Serbia
Get PDFThe aim of this study was to provide a quantitative exposure assessment to essential elements through the consumption of canned fish in Serbia. This objective was fulfilled by analyzing content of essential elements in canned fish and by using data from a food consumption survey. Consumption survey of canned fish was designed and performed to general principles and EFSA guidelines on data collection of national food consumption. The questionnaire was performed on 1,000 respondents during 2018. Determination of copper, zinc and iron levels were performed on 454 canned fish and seafood samples divided into four groups (canned tuna, canned sardines, canned other sea fish and canned seafood) during five consecutive years (2014–2018). This study showed significant association between sex, BMI and weight and consumption patterns. Obtained average weekly consumption of canned fish confirms our assumption that consumption of canned fish is significant in Serbia. Zinc and iron were found in all 454 samples (100%), and copper in 222 samples (48.9%). The average obtained concentration in all samples were 1.268 mg kg–1 for Cu, 5.661 mg kg–1 for Zn and 9.556 mg kg–1 for Fe. The highest concentration for all three minerals were found in canned sardines (Cu — 6.49 mg kg–1, Zn — 37.2 mg kg–1 and Fe — 21.8 mg kg–1). Obtained mean exposure to intake of copper, zinc and iron from canned fish was 1.2241 μg/kg bw/day, 5.4634 μg/kg bw/day and 9.2231 μg/kg bw/day, respectively. Exposure of Serbian population to zinc, copper, and iron through consumption of canned fish is less than recommended daily reference intakes and there is no risk of reaching toxic levels by consuming fish
Fortification of food with micronutrients: development of methodological and regulatory framework in the Russian Federation
Get PDFThe available scientific literature, domestic and international regulatory codes of normative documents concerning the fortification of various types of food products have been analyzed. The groups of food products of conventional and regular consumption included into the diets of all categories of consumers, recommended for fortification with essential micronutrients, have been determined: wheat and cereal flour (spelt wheat, buckwheat, oat, corn flour, etc.); pastry; milk and dairy products, including ice cream; non-alcoholic soft drinks; mineralized drinking water; fruit and vegetable juices; fat and oil products (vegetable oils, margarines, spreads, mayonnaise); confectionery and sweets (pastry, sugar, chocolate); cereals (breakfast cereals, muesli, ready-to-eat extruded cereals, instant pasta and cereals, mixtures for bakery, flour for sweet pastry); food concentrates (jelly, instant drinks, concentrates of sweet foods, instant food, instant cereal concentrates); table salt. The groups of food products assigned for certain categories of population are used as part of therapeutic diets for patients with various diseases (metabolic disorder syndrome, cardio-vascular system pathology with atherosclerotic vascular injury, type 2 diabetes mellitus, gastrointestinal tract diseases, non-alcoholic fatty liver disease, diabetic nephropathy, etc.), as well as assigned to reduce the risk of diseases developing, the nutrients are recommended for targeted fortification of certain types of food. Examples of micronutrients fortification of sausages and minced meat semifinished products are given below. Requirements for fortification of mass consumption food products and for fortification of foods for special dietary uses are formulated in this article, the amount of fortifying components in the various groups of food products are justified, ensuring their efficiency for improving the micronutrient status and safety of its consumption. Based on the analysis of the available scientific literature, domestic and international regulatory framework of normative documents on fortification of various types of food products, recommendations have been developed for fortification of food with micronutrients
Chicken egg white — characteristics of its properties and the prospects for functional foods development
Get PDFThe overview presents the literature data and the results of our own research on prospects of using the chicken eggs as the basis of functional foods. The composition of chicken eggs and their components, characteristics of egg white proteins properties are presented thereto. The biologically active compounds included into egg composition are analyzed. The data on the biological value of egg white are given. The characteristic of egg white foaming ability is presented. It has been shown that the ability of proteins to form stable intermolecular structures, especially with partially denaturated proteins, allows them forming viscoelastic superficial films that ensure foam stability. The high foaming ability of chicken egg protein macromolecules is directly related to their interphase properties, i. e. the ability to form interphase layers at the “liquid — gas” interface. The foaming properties of the various egg proteins are not equal, and therefore they contribute to foaming properties at various extents. The model of egg white proteins gelation is considered and the factors influencing the gelation process are described. It has been shown that very important changes in proteins properties are caused by denaturation. The proteins lose their ability to hydrate; the protective aqueous shell around the globules disappears, the proteins stick together, grow larger and lose solubility. This process is called coagulation. The influence of denaturation and aggregation on variations of protein properties is described below. Data on protein fortification with functional ingredients (calcium, iodine, plant polyphenols) and creation of functional egg and meat foods are presented here
Meat supply chain in the perspective of UN SDGs
Get PDFThis paper presents an overview of the meat supply chain in the perspective of main UN sustainable development goals (SDGs). To perform this overview, meat supply chain was presented with five main stakeholders (livestock farmers, slaughterhouses, meat processors, retailers and consumers). As this chain is specific, four SDGs have been revealed as most important, as follows: SDG6 — Clean water and sanitation; SDG7 — Affordable and clean energy; SDG12 — Sustainable consumption and production; SDG13 — Climate action. Discussion and literature review was performed for each of the four UN SDGs. In addition, other UN SDGs of interest for this supply chain have been briefly presented
An effect of the recipe composition on minced meat properties
Get PDFThe paper describes an experiment on the development of minced meat recipes for poultry-based semi-prepared products. The design principle included a search for optimal compatibility of recipe ingredients to develop a balanced meat system. The model recipes included meat from different animal and poultry species, by-products and dairy products. White and red turkey meat and chicken breast fillet provided recipes with complete animal proteins. Fat meat raw materials were partly replaced with milk fat. A semi-prepared product filled into an intestinal casing was named “sausages for grilling”. A technology of sausages for grilling was developed with the indication of the main control technological parameters for the production process and thermal treatment up to product readiness. The incoming control of raw material quality was carried out: dairy cream was assessed by acidity and pasteurization effectiveness; cheese by sensory indicators; meat raw materials by the pH value. The functional-technological properties of raw minced meat for sausages for grilling were compared before and after cooking by the pH level, moisture mass fraction, water binding capacity. The rheological properties of minced meat (adhesion, viscosity, shearing structural-mechanical properties) were studied. The expedience of introducing meat by-products and dairy ingredients into recipes of sausages for grilling to stabilize protein and fat in the meat system was substantiated. It was proved that replacement of the main raw materials in recipes with pork heart, ginger, cheese and chicken liver allows obtaining sausages for grilling with preservation of high quality indicators. Sausage sensory properties after grilling were analyzed
Do insects as feed ingredient affect meat quality?
Get PDF The development of sustainable feed ingredients for monogastric livestock is nowadays considering insect meals and oils to replace or supplement conventional feedstuffs. Although the regulation on the use of insect products differs among countries resulting in restrictions on use in the diets of monogastric meat producers, global research is exploring all the strengths and weaknesses of their inclusion. Therefore, whereas the scientific literature has extensively studied both the relationship between insect farming systems and safety (potential health risks), and between the dietary use of insects and the nutritional value of diets and production performance of farm animals (fish, poultry, swine, rabbit), the relationship between insect-containing diet and meat quality has only recently been considered. The present review therefore aims to collect the results of the studies that have related the dietary use of some insect species, such as the black soldier fly (Hermetia illucens), the yellow mealworm (Tenebrio molitor) and the silkworm (Bombyx mori), on the physicochemical and sensory traits of the poultry, swine and rabbit meat. The variable that has been most affected by the inclusion of insects as feed on livestock meat quality is the fatty acid (FA) profile, which, as is well known, in monogastrics tends to reflect that of the diet. Therefore, the black soldier fly inclusion has always originated meats with a more saturated FA profile, the yellow mealworm a more monounsaturated fatty acid profile, whereas the silkworm a more unsaturated fatty acid profile and rich of valuable omega-3 FA, but rarely changed the related physicochemical variables, or the sensory profile of the meat.
Comparative study of technologies for extraction of biologically active substances from the raw material of animal origin
Get PDFTechnologies of isolation and concentration of biologically active substances, developed in the middle of the 20th century, need adjustment and adaptation to modern conditions both to increase the activity of substances and for greater economic efficiency. The aim of the research is the comparison of dynamics of biologically active compounds extraction from porcines pancreas in two methods: the saline method based on 0.9% sodium chloride solution, and the acidic method based on 2.4% trichloroacetic acid solution. Also the purpose of research is to assess the possibilities for further optimization of technologies. The total protein concentration based on the biuret reaction in the samples taken during the extraction, as well as the calculation and analysis of the point degrees and rates of extraction are chosen as the controlled parameters. Local maxima of the protein yields into the extractant media at the 60th, 135th and 255th minute were recorded during saline extraction; and at the 75th and 135th minute during acid extraction. Also the proteomic profile of the extracts was studied. Wide range of compounds with molecular weight of less than 52 kDa was found in extracts based on physiological saline solution, and protein substances of whole presented range of molecular weights in trichloroacetic acid based extracts were considered. The predominance of low molecular weight protein fraction of interest was noted also in this method of extraction in comparison with the other methods of extraction. According to the UniProt database, we assume availability of probable compounds with a molecular weight of less than 30 kDa in the purified acidic extract. The presence of some proteins absent in the final saline extract was noted. The acidic erythrograms showed a weak degrading effect of both types of extracts on the membranes of rat erythrocytes, as well as the cytoprotective effect of acidic ultrafiltrates (less than 3 kDa). The obtained results prove a better efficiency of trichloroacetic acid extraction method used for obtaining a mixture of a wide range of compounds, including biologically active substances of low molecular weight